公司新聞
水泥撒布車安全操作規程你知道多少？
來源：http://hk-pinyan.cn/ 日期：2020-08-10
1汽車部分按汽車安全操作規程的規定進行操作。
1. The automobile part shall be operated according to the regulations of automobile safety operation regulations.
2檢查各操作部分、閥門、儀表、瀝青泵液壓系統等工作裝置是否正常。
2 check whether the operating parts, valves, instruments, asphalt pump hydraulic system and other working devices are normal.
3檢查防火器材及防護用品是否齊全有效。
3. Check whether the fire prevention equipment and protective equipment are complete and effective.
4嚴禁采用規定之外的燃油作為加熱系統的燃油，不允許燃油溢出箱外，一般油面應低于溢流管上端20-30厘米。
4. It is strictly forbidden to use the fuel beyond the regulations as the fuel of the heating system, and it is not allowed to overflow the tank. Generally, the oil level should be 20-30cm lower than the upper end of the overflow pipe.
5使用固定式噴燈向瀝青箱火管加熱時，應先打開瀝青箱后壁上的煙囪口，并須在液態瀝青淹沒火管后，才能點燃噴燈。
5. When the fixed blowtorch is used to heat the fire pipe of the asphalt tank, the chimney opening on the back wall of the asphalt tank shall be opened first, and the burner can be ignited only after the fire pipe is submerged by liquid asphalt.
6加熱噴燈的火焰過大或擴散蔓延時，應立即關閉噴燈，讓多余的燃油燒盡后再行使用。
6. When the flame of heating blowtorch is too large or diffused, the burner should be turned off immediately and the surplus fuel should be burned out before use.
7在吸油管及近料口尚未封閉時，以及在熱態瀝青的情況下，不得使用噴燈。
7 blowtorch shall not be used when the oil suction pipe and near material opening are not closed, and in the case of hot asphalt.
8手提噴燈點燃時，不允許接近易燃品。
8. When the portable blowtorch is ignited, it is not allowed to get close to inflammables.
9吸油作業時，要選好停車位置，車身停放平穩，各出口閥門應處于關閉位置。注意指針指示，及時停吸，防止瀝青外溢。
9. During oil absorption operation, the parking position should be selected, the car body should be parked stably, and each outlet valve should be in the closed position. Pay attention to the pointer indication and stop suction in time to prevent asphalt overflow.
10 滿載瀝青運行時，應中速形勢。遇有彎道、斜坡時，應提前減速，盡量避免緊急制動。
10. When running with full load of asphalt, the medium speed situation shall be adopted. In case of curve and slope, deceleration shall be conducted in advance and emergency braking shall be avoided as far as possible.
11 噴撒作業時，在噴撒方向10米內不得站人。
11 during spraying operation, no one shall stand within 10 meters of spraying direction.
12 噴撒時，應按引導線指示的方向，調整好車速平穩前進，不得任意擺動，猛轉方向盤和變速。
12. When spraying, the speed should be adjusted according to the direction indicated by the guide line, and the vehicle should move forward smoothly. It is not allowed to swing arbitrarily, turn the steering wheel violently and change speed.
13 瀝青撒布車在行使時，嚴禁使用加熱系統。
13. When the asphalt distributor is running, it is strictly forbidden to use the heating system.
14 撒布作業結束后，應使用瀝青泵將管道內的殘余瀝青吸回瀝青箱內。
14 after the spraying operation, the residual asphalt in the pipeline should be sucked back to the asphalt box by using the asphalt pump.
15 完成當天后，要加熱噴嘴，及時清除機上各部殘留的瀝青，進行例保工作。
15 days after completion, the nozzle should be heated, and the residual asphalt on each part of the machine should be removed in time for routine maintenance.
以上是關于水泥撒布車操作流程的相關內容介紹，希望可以幫到大家！
The above is about the cement spreader operation process related content introduction, hope to help you!
公司地址：濟南市槐蔭區經一路273號群盛華城2號樓1-404
公司名稱：山東途暢路橋工程有限公司 
備案號：